referral_links

gallery_videos

phone_override

Aggregate Systems Inc

FUEL TANK 7,300 GALLON, Vertical 7,300 Gallon Fuel Tank Inventory #: ACT1445 Make: N/A (Vertical Fuel Tank) Size: 7,300 Gallons Other Info: approx. 10ft x 15ft Tall Loading included Was used to store waste oil, has been cleaned out No holes or tears in skin Structurally sound tank

FUEL TANK 7,300 GALLON Tanks EQUIPMENT

(2) Stationary 200ton Standard Havens Silo Package (400ton Total)

Silo System:

<ul><li>Year: 1998 (approx.)</li><li>Capacity: (2) 200 ton</li><li>Stationary</li><li>The two (2) Standard Havens silos are a nominal 200 tons each.</li><li>Each silo has four inches of insulation on the sidewalls and cone and six inches on the top.</li><li>Sixteen gauge galvanized metal wrapper covers the insulation and the 12’ square top is checker plated for antiskid.</li><li>The 6-ton round anti segregation batchers are mounted to the top.</li><li>Electrically heated cones with electrically heated double gates.</li><li>There are high and low bindicators for material level indicators.</li></ul>

Conveyor:

<ul><li>Seventeen floating bearings located at five-foot intervals on the sidewalls to allow the slat to move up and over any floor obstruction to prevent damage to the chains or slats.</li><li>There is a mix reject gate in the floor. A 100 hp motor and a REX Neptune gear reducer power the conveyor.</li><li>There are stairs (1) one side of the conveyor to make maintenance easier.</li><li>There is hot oil heat on the sub-floor covered by insulation and metal covers and oil heat on the boot of the silo.</li></ul>

Notes: The pads on the silo legs were removed when the system was taken down, the silo cones and barrel walls look to need some repairs. The Silo Cones will need to relined. And there is (NO SILO TRANSFER). The silo's are down on the ground however there will be a $5,000.00 crane charge to load on buyers trucks.Slat at another location

STANDARD HAVENS 400 TON Silos EQUIPMENT

CEDARAPIDS 30 TON, Stationary 30 Ton (422BBL) Dust/Lime Silo Inventory #: DS1044 Make: Cedarapids Size: 30 tons Other: Operation 1 year ago 4‘‘ fill pipe from bottom to top 12‘‘ dust auger to move lime 1 HP cone vibrato Aeration pads on cone for smooth flow/air tank roof mounted Air locke/vane feeder Top mounted Baghouse included for dust control during loading Stout base for faster relocation Clean out door in cone 3 level indicators at low, mid and high levels Ladder from bottom to top and a roof railing

CEDARAPIDS 30 TON Silos EQUIPMENT

SILO 80 TON, Stationary 80 ton Silo Inventory #: SIL1214 Other: Newer Style Skinned To the Cone Insulated and Skinned Anti-Segrigation Batcher Side Ladder Down On The Ground With And The Legs have been removed and ready to load Bucket elevator is on the ground and ready to load

SILO 80 TON Silos EQUIPMENT

2 STORY CONTROL HOUSE, NEW 2 Story Control House Inventory #: CON1332 Sections: TWO Each section made of 2 x 3 steel tube framing with all corners made of 4" x 4" steel tubing [except the 4"x6" tubing on corner touching concrete pad. 2 levels bolted together and bottom anchored and welded to foundation 12 gauge steel 100% welded 360 degrees on both levels 3" insulation walls/ 6" insulation ceiling/ 3/4" plywood internally on all walls Stairs and Platform. Air/heat unit. Top: 7 tempered glass store front style windows 10 1/2 ft tall top floor having additional 1/4 office style paneling Bottom: Can also quote for Portable units and units including Computer Controls! (Additional Cost)

2 STORY CONTROL HOUSE Aggregate Equipment EQUIPMENT

CH CONTROL HOUSE, 8‘ X 20‘ Control House Inventory #: CON1554 8‘ x 20 Control House (Elevated Roof), Window Air, Single Axle with Pentel Hitch, Manual Controls, Gencor Burner Controls, Baghouse Controls, Cold Feed Controls, COMPUTERS ?, No Starters with Miscl Wire. The House has Broken Windows and is 280 Degree

CH CONTROL HOUSE Aggregate Equipment EQUIPMENT

HEATEC 35,000 GALLON, 35,000 Gallon Heatec A.C. Tank Inventory #: ACT1541 Heatec A.C. Tank Model TA 35 (SN# 93159) Year 1993 35,000 Gallon Split Compartment 20/15 Coiled Tank Insulated and Skinned Some coking

HEATEC 35,000 GALLON Tanks EQUIPMENT

8' X 40' CONTROL HOUSE, Portable (8‘ x 40‘) 280 Degree Control House Inventory #: CON1431 Size: 8‘ x 40‘ Portable Structure: The control house is in good condition. Box van trailer with 280 degree windows. Control House was on a 150tph Drum Plant The control house contains most of all the original books for the plant. Windows Controls: Auto Burner Controls Motor Starters (Soft Start on the Scrubber Fan) Easy Blend Computer Controls Above Ground Wire The controls are complete with a later model set of computer controls. The motor starters are original to the plant but in good functional condition

8' X 40' CONTROL HOUSE Aggregate Equipment EQUIPMENT

BARBER GREENE 80 TON, Portable 80ton Barber Greene Surge Silo Inventory #: SIL0987 Silo System: Make: Barber Greene Capacity: 80 Ton Portable Batcher Conveyor: Make: Barber Greene Portable slat conveyor Double chain Top door‘s (steel) Reject chute and side walkway (New floor) Oil heated floor Scales: Scales pitless 10‘ x 70‘.

BARBER GREENE 80 TON Silos EQUIPMENT

BARBER GREENE 3 BIN COLD FEED, Portable 3 Bin Barber Greene Cold Feed (8‘x8‘) Inventory #: CF0270 Number of Bins: 3 Make: Barber-Greene Bin Size: 8‘ x 8‘ Portable Other: Single Axle 8‘ x 8‘ Bins with Bin Extenders Set up for 3 hp A.C. Motor (NO MOTORS) Dodge Reducers 24" Variable Speed Feeders 24" Collecting Belt with motor and reducer 5‘ Stinger

BARBER GREENE 3 BIN COLD FEED Aggregate Equipment EQUIPMENT

BLOWER 60HP, 60HP Blower Inventory #: FB0838 Motor Size: 60hp Other: BLOWER On Stand 12‘‘ ductwork opening

BLOWER 60HP Aggregate Equipment EQUIPMENT

BDM 80 TON, Portable 80 Ton BDM Silo Package Inventory #: SIL1703 Make: BDM Size: 80 Ton Portable 80 Ton Portable Silo with 5 Ton Weigh Hopper Low tonnage units placed in service in 1994. Relined slat conveyor floor and replaced sprockets just prior to being replaced with larger silo system.

BDM 80 TON Silos EQUIPMENT

PHOENIX BURNER, PX-100 Heater Inventory #: HT1821 One Phoenix Thermal oil heater; model PX-100, maximum design temperature of 550F. Double Helical coil design with heatmizer fins for improved heat extraction from air stream. The unit will be complete and ready to fire after connecting to the electric, fuel, and hot oil circulation piping. The coil is designed according to ASME for 550F @ 125 psi MAWP. The coils are Schedule 40 SA-106B pipe. This unit comes with a reconditioned burner with a two year warranty on all burner parts. Includes the following specs: 6" inlet/outlet nozzles - ANSI 300# SA 105 WNRF flanges. ASME designed coils = 125 psi @ 550F. Double 3 helical coils. (Sch. 40 SA-106B Seamless pipe). The heater shall have high temperature refractory install in the turn-around area of the heater. Shell and front/back plates to be 304 SS 5/16" steel wrapped with 2" thick high temperature insulation covered with a galvanized steel skin. The heater shall be equipped with a 2" diameter sight glass (quartz) port equipped with a cooling connection located at the rear of the unit for an unobstructed view of the flame. The heater shall be equipped with a 20" (minimum) manway located at the rear door for internal inspection of the unit. The heater shall be equipped with sampling and instrumentation ports to be located on the stack and at locations before and after the convection section. All electrical conduit material shall be rigid aluminum. Controls Controls and control panels to meet NEMA 4 requirements and includes the following: UL Listed NEMA 4 enclosures. TEFC burner blower motor. Honeywell high oil temperature limit control. Love Controls TCS-4010 high stack temperature control. 1 - Stack dual thermocouple. Square D 500SV1B Step-down control transformer for 120V control power. Numbered terminal blocks and enclosed wire raceways. Alarm horn mounted to the control panel. Integrated shutdown permissive. Control Relays. Full set of dry contacts for alarms and statuses for customer use. Push/Pull emergency stop button located on control panel. Locally mounted instruments: Heater Inlet Piping: 1 pressure switch mounted between the heater inlet and outlet for 500 GPM flowrate. 1 - Inlet pressure gauge with shut off cock. 1 - Inlet thermometer with thermowell. 1 Inlet thermocouple. With thermowell. Heater Outlet Piping: 1 - Outlet pressure gauge with shut off cock. 1 - Outlet thermometer with thermowell. 1 - Outlet dual thermocouple with thermowell. 1 Outlet thermocouple with thermowell for circuit coil #1 1 Outlet thermocouple with thermowell for circuit coil #2 1 Flanged pressure relief valve (located on the heater outlet manifold). Pilot Fuel Train (Natural Gas): Pilot fuel train designed to meet typical NFPA-87 / NEC requirements. Pilot fuel tr

PHOENIX BURNER Heating, Cooling Equipment EQUIPMENT

CF BIN 3 BIN COLD FEED, Portable 3-Bin Cold Feed Inventory #: CF1357 Number of Bins: 3 Bin Size: 12‘ X 14‘ Other: Portable missing from section and king pin 2 axle Granite number 83-077 Has 3 hp motors and gearbox Holds 30 feeder and gathering belts Missing belts Missing discharge stinger section 12x14 bins Rough shape

CF BIN 3 BIN COLD FEED Aggregate Equipment EQUIPMENT

AC TANKS 10,000 GALLON, Portable 10,000 Gallon Coiled A.C Tank Inventory #: ACT0716 Make: N/A (Coiled AC Tank) Size: 10,000 Gallon Portability: Portable (Skid Mounted onto a Flatbed Truck) Interioir: Some Coking Heating Indirect "Coiled" Other Info: Ladder to Top Miscellaneous Equipment basket Mounted Under Trailer Tandem Axle

AC TANKS 10,000 GALLON Tanks EQUIPMENT

YANKEE 100 TON, Portable 100ton Silo Package and Weighbatcher Inventory #: SIL0748 Silo System: (1) Yanke Fabrication 100 ton portable silo Insulated and skinned truck load out silo w/air gates Anti Segregation Batcher Single gate dump Not Self-erecting, Single Axle Weigh Batcher Cone and Gates heated by Transfer Oil Cone Thickness: (Top) .28 (Middle) .27 (Bottom) .27 Conveyor: (1) Yanke Slat Conveyor Portable w/ electric motor and drive 400tph Single axle Floor heated by transfer oil Duel chain, chain and slat in good condition Head and tail pulley in good condition Thickness: (Floor Near Head Pulley) .52 (Floor Near Tail Pulley) .51 (Sides) .26 NOTES: Units on ground and ready for loadout (Road readiness should be checked by local technician)

YANKEE 100 TON Silos EQUIPMENT

STEELHEAD SEB, Portable 70ton Steelhead SEB Inventory #: SEB0749 Make: Steelhead Year: 1995 S/N: 94856 Capacity: 70 ton Stationary drive under truck load out hopper 24‘‘ x 45‘ drag slat conveyor w/electric motor &amp; drive, air gates electric air compressor Hydraulic self-erecting raise and lower system Mounted on T/A chassis Missing 2 load cells

STEELHEAD SEB Silos EQUIPMENT

JUMPER SLAT 46, Portable 46‘ Jumper Slat Conveyor Inventory #: SL0855 Make: Jumper Slat Conveyer Portability: Portable Other Info: 100hp Drive package Unit Used To Have Heat, the Cavity is There for it, but the Pipes and Cover for the Cavity have been removed.

JUMPER SLAT 46 Aggregate Equipment EQUIPMENT

BARBER GREENE 70,000ACFM WETSCRUB, 70,000acfm Barber Greene Wet Scrubber - Portable Inventory #: WETS0760 Brand: Barber Greene SN: 14Y1UO ACFM: 70,000 Other Info: Portable High Capacity Dual Circuit Exhaust Fan Dust Collector System(SN: 14Y1UO). With dual 100 HP Electric Fan Drives, mounted on T/A Drop Deck Trailer. Portable High Capacity Hot Plant Dust Collector/Scrubber w/dual blower intake ducts, emissions stack, water injection, venturi wet misters, and all tube and duct attachments. Tank Thickness: (Front) .21 (Middle) .20 (Back) .20 Note: Trailer not included with fan

BARBER GREENE 70,000ACFM WETSCRUB Baghouses, Dust Collectors EQUIPMENT

BARBER GREENE HOT ELEVATOR, Stationary 300tph Barber Greene Hot Elevator Inventory #: BE0199 Make: Barber Greene Output: 300tph Model: AE-175x880. Other: Dodge Reducer (Missing 50 HP Motor) Reject Chute Single Chain Box and Chain in Good Condition Down on Ground Ready to load

Aggregate Systems Inc

Search Filter

Refine Search

Type

Distance

Listing Type

Category

Make

Model

Price

Condition

Hours

Year

Country

State

City

Class

FUEL TANK 7,300 GALLON

STANDARD HAVENS 400 TON

CEDARAPIDS 30 TON

SILO 80 TON

2 STORY CONTROL HOUSE

CH CONTROL HOUSE

HEATEC 35,000 GALLON

8' X 40' CONTROL HOUSE

BARBER GREENE 80 TON

BARBER GREENE 3 BIN COLD FEED

BLOWER 60HP

BDM 80 TON

PHOENIX BURNER

CF BIN 3 BIN COLD FEED

AC TANKS 10,000 GALLON

YANKEE 100 TON

STEELHEAD SEB

JUMPER SLAT 46

BARBER GREENE 70,000ACFM WETSCRUB

BARBER GREENE HOT ELEVATOR