referral_links

gallery_videos

phone_override

Aggregate Systems Inc

FLOP CHUTE CHUTE, Flop Chute Inventory #: FC1664 This remote control flop chute feed system is currently on a 6,000# batch plant feeding a 300 TPH drag slat conveyor. It includes all index railing and the air cylinder for interaction or extraction. It includes a vibrator on the lower chute. It is in very good condition.

FLOP CHUTE CHUTE Silos EQUIPMENT

BITUMA STOR 100 TON, 100TON Bituma-Stor Silo System w Matching 300tph Drag Inventory #: 1SS1622 100Ton Silo System Make: Bituma-Stor Model: 100Ton- 100T-138-22-71-SA Drag: Matching 88‘ 300tph Drag Slat Conveyor- 300-tph-56-20-71-SA Other Info: The cones are in good condition The ni-hard casting floor is in very good condition. approx. 90% LIFE LEFT The single 6‘‘ pitch chain is 65%+ The slats need replacing. The bottom of the silo is totally enclosed. The system is being replaced by twin 200 ton silos. The manual is included. Silo system is now disassembled and on ground and ready for load out. Loadout Cost‘s on Buyer,

BITUMA STOR 100 TON Silos EQUIPMENT

CEDARAPIDS TWIN SHAFT, Portable Cedarapids twin shaft Pugmill Inventory #: PG1593 Cedarapids Twin Shaft Pugmill, turns freely On Board Power (Diesel Engine), Detroit 671, condition unknown Tandem Axle for Portability, roadreadiness eeds to be checked or loaded on a trailer The pugmill does not come with a any conveyors or bins, it is just the pugmill.

CEDARAPIDS TWIN SHAFT Pugmills EQUIPMENT

BARBER GREENE BUCKET ELEVATOR, Barber Green Bucket Elevator Inventory #: BE1206 Make: Barber Greene Model: AE120L919 Portable Other: Buckets are original. New paint. Chain has one season of operation on it, approx. 70,000 ton. single axle. Drop shoot can be removed or cut to desired discharge height.

BARBER GREENE BUCKET ELEVATOR Aggregate Equipment EQUIPMENT

HEATEC PRE-HEATER, Heatec Fuel Pre-Heater Inventory #: HT1266 Make: Heatec Model: HFP-100R SN#: H04-304 Year: 12-04 Other: Inline Hot Oil (Thermal Fluid) Heated Fuel Pre- Heater Fuel Pump Duplex Filters Modulating Controls (For Maximum Fuel Savings) Skidded Fuel Pre-Heater

HEATEC PRE-HEATER Heating, Cooling Equipment EQUIPMENT

70' ScalesInventory #: SC1252

Pittless Scales Make: INSCALE 70' Long 2-Section 35' Steel Deck (Removable) Model 5752-70-200-10S CLC 80 SN# 26054 Cap 200000 ONLY 5 load cells included Intep Certified Stacked out ready for loading. Loadout cost on buyer

PITLESS 70 Floor Scales EQUIPMENT

SILO SYSTEM 200 TON, Stationary 200ton Silo Inventory #: SIL0577 Silo System: Capacity: 200 ton On the ground and ready to be moved to a new home The unit appears to be in very good condition but it needs paint Upon inspection there are no rusted thru areas; all rust appears superficial. The unit is heavily insulated and covered with a 10 gauge metal wrapper. The superior style batcher is the double split variety; this style has proven not to segregate materials. The cone of the silo is covered with ceramic tiles. These tiles have shown to be the best guard against heavy wear in the cone area. The tub of the silo appears to be structurally sound. OPTIONAL Bintop Conveyor (Additional $): ASI has a bintop conveyor that could be sold with this unit. It is 400 tph, 14‘2‘‘ shaft to shaft, with the flop gate extension of 34‘‘. It utilizes a double 4‘‘ pitch roller chain (60% remaining). The floor appears to be in very good condition. The unit has NO motor and drive

SILO SYSTEM 200 TON Silos EQUIPMENT

PREHEATER NEW, NEW Fuel Oil Preheater Inventory #: HT1681 Capable of heating up to 1000 gallons per hour (averages 600-1000gals per hour) Heated via hot oil Insulated preheater Oil to oil heater- heats fuel oil Comes ready to accept inch and a half oil lines and inch and a hald hot oil lines Available to ship within 3 to 4 weeks of order

PREHEATER NEW Heating, Cooling Equipment EQUIPMENT

STANSTEEL ZF-50, Stansteel Fan - Model: ZF-50 Inventory #: FB0969 Stansteel Fan 3‘ opening Model ZF-50 No 2016 Lifting eyes Spins freely No motor or gearbox Fan is scrap the impeller is wore out (The Housing Is Good)

STANSTEEL ZF-50 Aggregate Equipment EQUIPMENT

TRANSFER SLAT 17, Stationary 17‘ Transfer Slat Conveyor Inventory #: SL0974 Make: Transfer Slat Length: 17‘ long Portability: Lifting Eyes Other Info: Length: 17 Width: 5 Height: 5 Shaft to Shaft: 140 Double Chain Slats are 34 Motor is 30hp Box Opening is 2 x 2 Metal Thickness (Floor on Motor End): 0.385 Metal Thickness (Floor in Center): 0.370

TRANSFER SLAT 17 Aggregate Equipment EQUIPMENT

DWYER MAGNEHELIC PRESSURE, Dwyer Magnehelic Pressure Gage Inventory #: MISC1744 Dwyer 2030 Differential pressure gage, Range 0-30‘‘ w.c. (inches of water), minor divisions 1.0. Using Dwyer‘s simple, frictionless Magnehelic Gage movement, it quickly indicates low air or non-corrosive gas pressures--either positive, negative (vacuum) or differential. The design resists shock, vibration and over-pressures. No manometer fluid to evaporate, freeze or cause toxic or leveling problems. It‘s inexpensive, too. The Magnehelic Gage is the industry standard to measure fan and blower pressures, filter resistance, air velocity, furnace draft, pressure drop across orifice plates, liquid levels with bubbler systems and pressures in fluid amplifier or fluidic systems. It also checks gas-air ratio controls and automatic valves, and monitors blood and respiratory pressures in medical care equipment. The Duel Gage Set Up Is In a NEMA Box with Idec Izumi Power source and Electrical Junction Block

DWYER MAGNEHELIC PRESSURE Aggregate Equipment EQUIPMENT

POLY-STAGE ESP, Poly-Stage Electrostatic Inventory #: PE0964 Poly-Stage electrostatic Model: 46-80KVA 1ph 60HZ S/N: 86-1921 Other: An electrostatic precipitator (ESP) is a filtration device that removes fine particles, like dust and smoke, from a flowing gas using the force of an induced electrostatic charge minimally impeding the flow of gases through the unit. In contrast to wet scrubbers which apply energy directly to the flowing fluid medium, an ESP applies energy only to the particulate matter being collected and therefore is very efficient in its consumption of energy (in the form of electricity).

POLY-STAGE ESP Aggregate Equipment EQUIPMENT

A&amp;D WEIGHING INDICATORS, (2) A&amp;D Weighing Indicators Inventory #: MISC1743 (2) A&amp;D Weighing Indicator Model AD-4323 (1) SN# C7312131 (2) SN# 7311723 We believe both to be in working condition but sold AS-IS

A&D WEIGHING INDICATORS Aggregate Equipment EQUIPMENT

40' TRUSS CONVEYOR, 40ft Trusss Conveyor Inventory #: CV1644 This truss conveyor is 40ft long, 24inch belt, 36inch total width. No motor or drive, trough idlers are good and belt and frame are good.

40' TRUSS CONVEYOR Aggregate Equipment EQUIPMENT

2 Single Phase Transformers Inventory #: MCC1725 1-Square D Company Transformer. Single Phase. Style # 1151-12212-010 Cat # 2553H

 1- F-F Tranformer.  3099/177 K 96-85 8800/ 48-1

 Please call ASInc for additional info 615-494-1210

WESTINGHOUSE TRANSFORMERS Aggregate Equipment EQUIPMENT

WEB HMB3000, Batch Plant Controls - Model: WEM HMB 3000 Inventory #: CON0579 Make: WEB Model: HMB 3000 batch plant controls Other: Controls worked fine at plant shut down a few years ago. Controls were on a 6,000lb h&amp;b batch plant.

WEB HMB3000 Aggregate Equipment EQUIPMENT

Blue Smoke ControlsInventory #: BSK1731

Blue Smoke Controls

Dwyer PHOTOHELIC

Motor Speed Indicator

Start Stop Buttons

Breakers and Starter

Allen-Bradley Power Flex 70 VFD

Nema Box

Allen Bradley 50 AMP 3 pole 600/250

50V transformer 4/10 amp 600v

6/10 amp 600 volts

DWYER PHOTOHELIC BLUE SMOKE CONTROLS Aggregate Equipment EQUIPMENT

AC TANK 20,000 GALLON, NEW Vertical 20,000 Gallon Electric Tank Quote Inventory #: ACT1592 Vertical Asphalt Tank Heat source: Electrically heated Size: 20,000 Gallons Specs: constructed of 1/4" plate and will have Electric 52kw elements in bottom of tank Standard features: 18" Manway on top 24" Diameter manway on bottom for clean out Caged ladder on top Bolt on handrail around top with toe plate Gauge board level indicator Tank thermometer in drywell 4" Vent and overflow line 3" Fill line with valve 3" Supply line with valve 3" Return line with valve 6" Fiberglass insulation on top 3" on bottom 6" Fiberglass unsulation on sidewalls Aluminum jacket covering .032 thickness Tank is equipped with high and low limit switches to deviate hot oil when tank is empty and also sound an alarm or cut off asphalt unloading pump when tank is full Tank is completely prewired to bottom of tank Tank is equipped with an alarm on mixer motor, if overloads trip an alarm will sound Sampling valve 15-30k GALLON TANKS AVAILABLE- HORIZONTAL OR VERTICAL! Other Info: The Mixer will be right angle euro drive helical bevel speed reducer flange mounted. 45rpm mixer with 10hp motor. Tank will be equipped with 3 sidewall baffles to prevent certrifige effect on mixing Photos are of recently made tanks that are similar 6-8 weeks lead time (may vary) Also available is piping/ insulation installation to incorporate tank into your project. 40+ years with tanks and Heatec references Terms: 40% down payment 60% due @ shipment

 

AVAILABLE UNTIL OCTOBER 2023

AC TANK 20,000 GALLON Tanks EQUIPMENT

NEMA MOTOR CONTROL CENTER, NEMA Motor Control Center Inventory #: MCC0490 Make: Nema 1200 Amp Main Plus a 300 Amp Main Ran a 350 TPH Drum Plant Large Nema Cabinet Starters For: Drum Baghouse Slat Conveyors Compressors, Augers Screen decks Heater Burner Pugmill ETC

NEMA MOTOR CONTROL CENTER Aggregate Equipment EQUIPMENT

BARBER GREENE 6,000LB, Stationary 6,000lb Barber Greene Batch Plant Inventory #: BP1022 Make: Barber Greene Output: 6,000lb (approx 200-225TPH) Stationary See ASIEQUIPMENTSALES.COM for more info

Aggregate Systems Inc

Search Filter

Refine Search

Type

Distance

Listing Type

Category

Make

Model

Price

Condition

Hours

Year

Country

State

City

Class

FLOP CHUTE CHUTE

BITUMA STOR 100 TON

CEDARAPIDS TWIN SHAFT

BARBER GREENE BUCKET ELEVATOR

HEATEC PRE-HEATER

PITLESS 70

SILO SYSTEM 200 TON

PREHEATER NEW

STANSTEEL ZF-50

TRANSFER SLAT 17

DWYER MAGNEHELIC PRESSURE

POLY-STAGE ESP

A&D WEIGHING INDICATORS

40' TRUSS CONVEYOR

WESTINGHOUSE TRANSFORMERS

WEB HMB3000

DWYER PHOTOHELIC BLUE SMOKE CONTROLS

AC TANK 20,000 GALLON

NEMA MOTOR CONTROL CENTER

BARBER GREENE 6,000LB